Go BottomEngine shaking JD 5510
 | tekts9
Join Date: Aug 2005 Posts: 7 Colorado 
|
2005-09-15 116443
Recently purchased a used JD 5510, 690 hours, reverser trans. It's a great tractor except for 1 problem. At various different engine rpm speeds the engine shakes a lot. Usually from 2000 to 2300 rpm & at slow < 1000 speeds. The exhaust pipe acts like it will come off & even the body panels vibrate. I my 2640 never did this. The 5510 I rented from a dealer didn't have this problem. What am I looking at? Also, I use this tractor with a new Woods batwing 15 ft mower BW 180. When the mower is running I get the same shaking, but at diffferent rpms.
Reply to |
Quote Reply |
Add PhotoEngine shaking JD 5510
 | Chief
Join Date: Jul 2003 Posts: 4302 Southwest MiddleTennessee 
 Pics
|
2005-09-15 116444
Does the exhaust smoke up noticably more when the shaking and vibrating occurs? ....
Reply to |
Quote Reply |
Add PhotoEngine shaking JD 5510
 | harvey
Join Date: Sep 2000 Posts: 1551 Moravia, NY 
Pics
|
2005-09-16 116477
Most likely a bad injector. However there could be a few more serious concerns. But a good mechanic on site is really what you need to check if something is out of balance, came apart or broken. ....
Reply to |
Quote Reply |
Add PhotoEngine shaking JD 5510
 | oneace
Join Date: Mar 2004 Posts: 1490 south central pa
Pics
|
2005-09-16 116492
Certain engines have a "spot" in the rpm where they shake. Usually at idle and then again at a higher rpm (with odd numbered cyl.) With 4 or 6 cyl. engines they will normally only shake at idle. I would watch that the balancing shaft is timed right. ....
Reply to |
Quote Reply |
Add PhotoEngine shaking JD 5510
| Kim Duleff
Join Date: Posts: 1
|
2005-09-16 116537
No. But any time I blip the throttle the exhaust emits a small black puff. ....
Reply to |
Quote Reply |
Add PhotoEngine shaking JD 5510
 | Peters
Join Date: Feb 2002 Posts: 3034 Northern AL
Pics
|
2005-09-16 116540
This might be a simplistic question but have you added any fuel conditioner. It could just be bad diesel or a little water in the tank. ....
Reply to |
Quote Reply |
Add PhotoEngine shaking JD 5510
| Chief
Join Date: Jul 2003 Posts: 4302 Southwest MiddleTennessee
Pics
|
2005-09-17 116547
Sure does sound like a weak injector. You may have to isolate each injector by loosening each tube nut to each injector individually while this rough idle conditon it occuring. Loosen each nut and observe if the idle shake gets worse or if no effect takes place. The injector that on effect takes place is probably the weak or bad injector. Pull that injector and take it to get pressure tested. ....
Reply to |
Quote Reply |
Add PhotoEngine shaking JD 5510
| tekts9
Join Date: Aug 2005 Posts: 7 Colorado
|
2005-09-29 117115
I am a somewhat good mechanic. I am looking for advice on what else I might look for,other than injectors. Also where can I buy a factory service manual for the 5510 W/, MFWD, reverser trans. Thank you. KD. ....
Reply to |
Quote Reply |
Add Photo
Go Top
Share This