Go BottomKubota TG1860D
 | Robert bROWN
Join Date: Posts: 1 
|
2006-05-08 129113
My TG 1860D bogs down when I go up hill. It's like it's starving for fuel. I've changed the filters, emptied and ghanged the fuel and checked to make sure the fuel pump is working. tHERE ARE 2 FUEL LINES THAT GO INTO THE FUEL TANK, ONLY 1 HAS A TUBE , IS THAT RIGHT? cAN ANY ONE HELP?
rOBERT
Reply to |
Quote Reply |
Add PhotoKubota TG1860D
 | earthwrks
Join Date: Dec 2003 Posts: 3853 Home Office in Flat Rock, Michigan 
 Pics
|
2006-05-08 129123
Could the one without a tube be a return or vent line?
Might be a governor issue---what happens when you give it more throttle when it bogs? ....
Reply to |
Quote Reply |
Add PhotoKubota TG1860D
 | Art White
Join Date: Jan 2000 Posts: 6898 Waterville New York
Pics
|
2006-05-09 129152
Is it smoking when this happens? ....
Reply to |
Quote Reply |
Add PhotoKubota TG1860D
 | bloggins
Join Date: Apr 2006 Posts: 104 Kingston, Ontario
Pics
|
2006-05-10 129207
Maybe the fuel tank isn't venting properly, check the gas cap for a blockage. ....
Reply to |
Quote Reply |
Add PhotoKubota TG1860D
| Art White
Join Date: Jan 2000 Posts: 6898 Waterville New York
Pics
|
2006-05-11 129212
Have you checked for water in the fuel? ....
Reply to |
Quote Reply |
Add PhotoKubota TG1860D
| earthwrks
Join Date: Dec 2003 Posts: 3853 Home Office in Flat Rock, Michigan
Pics
|
2006-05-11 129231
Two things come to mind: 1.) Could be a vacuum condition in the tank due to a clogged vent. Try this: After the engine bogs immediately open the fuel cap and listen for vacuum. If present, either clean the vent in the cap or replace it. 2.) That solenoid is likley the fuel cutoff solenoid. Sounds like it is internally shorted since it takes awhile to heat up which draws more amps then it weakens which cause it to shut off the fuel. Try this: when it bogs immediately touch its casing and see if it is hot to the touch. If very hot, it's probably shot. Alo check for loss of power at the terminal---broken or bad wire at the terminal could be causing short or loss of power to it. The solenoid should be controlled by a relay and this could be also getting hot internally or just not working properly. ....
Reply to |
Quote Reply |
Add PhotoKubota TG1860D
| earthwrks
Join Date: Dec 2003 Posts: 3853 Home Office in Flat Rock, Michigan
Pics
|
2006-05-11 129239
If it's like my blue, it can't be bypassed as it's part of the injection pump assembly (but the solenoid itself can be removed but fuel would pour out). ....
Reply to |
Quote Reply |
Add PhotoKubota TG1860D
| unipart
Join Date: May 2006 Posts: 2 Toronto
|
2006-06-06 130558
There were earwigs stuck in the fuel line. The dealer said $265.00 thank you very much!!!!!!!!!!! ....
Reply to |
Quote Reply |
Add PhotoKubota TG1860D
| bloggins
Join Date: Apr 2006 Posts: 104 Kingston, Ontario
Pics
|
2006-06-06 130565
I cleaned out the gas tank on my British sportscar and I was amazed at the amount of bugs (dead beetles) that were sitting on the bottom of the tank. I mean are bugs attracted to gasoline? I can only think that the previous owner must have had the tank sitting on a shelf allowing bugs to crawl around inside. I cleaned the tank out because I was experiencing sporadic shutdowns of the engine while driving. It was a loose washer from the float that would occasionally drift over the intake pipe and get sucked onto the tube causing fuel starvation. ....
Reply to |
Quote Reply |
Add Photo
Go Top
Share This