Go Bottomcooling fan
 | pilotboat
Join Date: Mar 2009 Posts: 2 Indiana 
|
2009-03-15 161081
My 2002 gator 6X4 gas water cooled kawasaki engine is over heating and the electric cooling fan wont turn on. I have replaced the temperature sensor in the radiator but, the electric cooling fan wont turn on while in the radiator. I pulled the temperature probe out of the radiator and heated it up with a heat gun and this DID make the fan turn on. The top hose on the radiator is hot and the bottom one is cold. Any ideas?
Thanks,
Kurt
Reply to |
Quote Reply |
Add Photocooling fan
 | earthwrks
Join Date: Dec 2003 Posts: 3853 Home Office in Flat Rock, Michigan 
 Pics
|
2009-03-15 161082
Sounds like the thermostat to me. ....
Reply to |
Quote Reply |
Add Photocooling fan
| gatoraider
Join Date: Nov 2008 Posts: 544 Maryland 
|
2009-03-16 161095
If your top radiator hose is hot all the way to the radiator and your bottom hose is cold you must have a clogged radiator, or a clogged lower hose. If your top hose is just hot next to the motor and not all the way to the radiator you may not be pumping coolant. You need to remove the bleeder screw in the intake manifold next to the 90 fitting for the carb ( 12 mm wrench ) and see if there is coolant present. If not fill 'er up, put the screw back in and try it. I've had air locks occur multiple times there so try it and check it. Be sure your temp light is working, it should come on when the ignition is in the start position. I've never seen a water pump fail to pump, so I doubt if it's that. ....
Reply to |
Quote Reply |
Add Photocooling fan
 | jbjpam
Join Date: Jun 2007 Posts: 39 Mid Michigan
Pics
|
2009-03-16 161124
Gatoraider has it correct. Exact same problems I used to have with mine (fan and hoses) You must fill that little hole to the top. I did it while running and water pumping to be sure it was full. No problems from then on. I also put an override toggle switch on the fan control just in case. It would let it run all the time if I wanted. ....
Reply to |
Quote Reply |
Add Photo
Go Top
Share This