Tractorpoint Login

print < Tractorpoint Login

Search for =

Topic

Didn't see a response on the limited slip additive other than the Deere product. Have some left over from a 94 Blazer restore.

Same CX with a squeaky brake. I did change the rear fluids last year but the manual said nothing about an additive. Just hit 1200hrs so rear drive has maybe 200hrs.

Very Noisy Rough Wet Brake on Gator CX
Utility Vehicles UTV/ATV
Replies 6 Post by appyacres

Question 1; Anyone had this problem before?

On some older motorcycles I have seen this. Fuel related mostly. If you were to apply the choke about half way, does it run longer or better? What about full choke?

For the coil troubleshooting I would attach a spark tester; an inline wire with glass tube that shows if the coil is sparking strong enough. If your tester shows the spark doesn't quit when it dies, then you probably have a fuel problem.

The tank vent hose can become pinched so immediately open the cap after it dies. If you can hear the pressure release, you know the vent is plugged. If that's not it I would install a clear fuel line so you can observe the fuel. It's normal to have air in the line, but if it goes entirely empty you may have a fuel pump issue.

Trying to find a loose wire Maybe Rectifier
Utility Vehicles UTV/ATV
Replies 8 Post by appyacres

Fusible link melted from starter to three wire joint.

About the worst possible way to connect a 3 to 1 connection. Even if I get a fusible link, trying to connect it to the splice is going to be a real bitch. Time to get creative...

I need a link to a Gator CX Technical Manual
Utility Vehicles UTV/ATV
Replies 7 Post by appyacres

[QUOTE=gatoraider;173836] You need to have the red wire hot going into the ignition switch. If that is hot, the transaxle has to be in neutral to activate the neutral safety switch. You can run a jumper wire across the plug going to the switch and try it. Purple wire out of the safety switch goes to the starter solenoid. That purple wire should be hot when the ign switch goes to start. [/QUOTE]

If the red wire is not hot, any suggestions then?

Gator will not start
Utility Vehicles UTV/ATV
Replies 9 Post by appyacres