Tractorpoint Login

print < Tractorpoint Login

Search for =

Topic

Check out this other forum page link below. You may have a sticky primary or secondary clutch, bad bumpers on the secondary clutch or a problem inside the primary clutch (springs, etc). But a belt would be an early try before spending money on clutch parts. Good luck.

Why Does My Gator Jerk
Utility Vehicles UTV/ATV
Replies 7 Post by bmeyer123

Try removing starter and file flywheel teeth and starter gear teeth. A mushroomed backlash develops and doesn't allow starter to engage. Good luck.

Gator starter engaging problem
Utility Vehicles UTV/ATV
Replies 4 Post by bmeyer123

You will find that a sticky clutch shaft (primary or secondary) which is not fully closing at idle, may result in dificulty shifting in/out of gear forward/reverse.

John Deere AMT 622 5-wheel gator help
Utility Vehicles UTV/ATV
Replies 4 Post by bmeyer123

On any engine, when you need to keep a choke on, my experience has been a dirty/ clogged carburator jet passage. I have disassembled carburators more than once to blow air through the passages. Usually I take a very fine wire (sometimes a wire brush pulled out with a needle nose) and push through the ports and jets. Remember to replace/ install and in-line gas filter, or you'll probably repeat this several times. It may be necesary to flush the gas tank too. Good luck.

Gator will not run without choke
Utility Vehicles UTV/ATV
Replies 2 Post by bmeyer123

If the calipers are not ground up from operating with no pads, you can rebuild them with parts from JD dealer. It is not fun to replace the pads though, but I've done it a couple of times. Be careful about disasembling them too far. Do only one at a time. You may need seals and bumpers, but if you're careful, probably not. Go to JDParts.com for a free diagram. Good luck. I would take it off your hands if you were closer :) Take your time & be patient. The brakes are the most frustrating part of the AMTs.

john deere amt 600 5 wheel gator
John Deere Tractors
Replies 3 Post by bmeyer123

Do you still have the AMT 626?

Looking for body parts-89 amt 626
Utility Vehicles UTV/ATV
Replies 10 Post by bmeyer123

Try removing starter and file flywheel teeth and starter gear teeth. A mushroomed backlash develops and doesn't allow starter to engage. Good luck.

Turf Gator Clicks but will not start
Utility Vehicles UTV/ATV
Replies 3 Post by bmeyer123