My Gator has driven smooth as silk for 10 years. Routine maintenance has served me well. Recently while driving along at a cruise speed of 5mph it coughed and slowed to a snails pace. With full throtle it would not accelerate past 10' per minute. I replaced spark plug, removed and cleaned carb, cleaned with compresses air. Checked fuel and pump for proper operation all ok. While it does start it will not rev to max rpm. It sort of boggs down at full throtle. Any suggestions for repair would be appreciated. Thank you in advance.
How about the fuel filter? Air filter? Also did you take the carb apart? Main jet and tube out, air jet out, air screw out, needle out. Sometimes the main jet gets build up and has to be cleaned with a tourch tip cleaner. All jets and orifices should be cleaned with carb cleaner thru the small nozzle provided with the can and blown out with compressed air several times.
I did change the fuel filter and air filters. I think I did a good cleaning job on carb. I will pull it off and clean again. I did not remove air mixture screw.I am sure it has to be fuel system. It sounds like you believe the same. Thanks for the wisdom and encouragement!
Removed carb and cleaned again. Reassembled with no change in operation. Played with choke, choke works as it should. I am stumped! I had previously replaced the spark plug with no change in operation. Is there anything electrical that might be happening? This motor ran perfect and died while running at 5 mph. Thank you in advance for any further input. Best, Kevin
While you are running or trying to accelerate, pull the choke out some and see if you can get it to run better or worse. If you can control the running with the choke there is a good chance it is fuel, if not, it could be electrical. Is there a small silver ignitor on top of the motor? It has a black wire going into it.
Someone Please Help. I have a early 90s Gator 4x2. I was riding and it was like someone fliped a switch. The Gator died and was really hard to start. Now it cranks over but does not want to start. I replaced the plugs 4 times. I purchased a new ignition coil and still the same problem. I took the carb apart and cleaned it out with carb cleaner. I can get it started but while driving I have to keep my hand on the choke in order to accelerate. The choke my be in a certain position inorder to start or run.
Gatoraider, you seem to be a very helpful resource on this site. Thank You. I was just wondering if you know where I can get Tie Rod ends for my 1992 4x2 gator. The dealer wants too much for them. Do you know if there are after market tie rod ends that would fit. Thanks for any help you can provide.
Rough running 4X2: John Deere Gator -- Utility / ATV Discussion Forum
Winchester AA once fired 12 Ga
Winchester AA hulls for sale
case 450b fuel problem
04-06-2010, 11:32 
Digg It 
Del.icio.us 
Technorati 
Furl 
Stumble This 